The fuel pump in your Audi is connected to the fuel tank with a flange that needs special sealant to prevent fuel leaks. Some of these flanges were repaired with temporary tape in a previous recall, but that tape may not be enough.
Risk if Unfixed
If the fuel leaks, it could ignite and cause a fire, especially if you're in a hot engine compartment or near an open flame.
Free Fix
Your Audi dealer will replace the fuel pump flange with a new one and apply a proper sealant to prevent leaks, all at no cost to you. You should schedule the repair as soon as possible once you receive the recall notice.
Show original NHTSA language
Original — What Happened
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.
Original — Risk if Unfixed
The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
Original — Remedy
Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
The fuel pump flange in your Audi is a small part that connects the fuel pump to the fuel tank. Over time, it can crack and let fuel escape.
Risk if Unfixed
If the flange cracks while you're driving, fuel could leak out and catch fire. This is a serious risk that could cause a fire in or around your vehicle.
Free Fix
Your Audi dealer will inspect the flange and fix it for free. If it's cracked, they'll replace it. If not, they'll clean and protect the flange with a special rubber band to prevent future problems.
Show original NHTSA language
Original — What Happened
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.
Original — Risk if Unfixed
A fuel leak in the presence of an ignition source increases the risk of a fire.
Original — Remedy
Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20W9.
The Gross Axle Weight Rating (GAWR) label in your Audi Q7 shows the maximum weight your vehicle can safely carry. Unfortunately, the label in certain 2009-2015 models has the wrong information, which could lead to overloading.
Risk if Unfixed
If you overload your Q7, you could be more likely to get into an accident, which could cause serious damage to your vehicle or even injury.
Free Fix
Your Audi dealer will add a new label with the correct weight rating on top of the existing one, and this repair is completely free. You should schedule the update as soon as you receive the recall notice.
Show original NHTSA language
Original — What Happened
Volkswagen Group of America, Inc. (Audi) is recalling certain 2009-2015 Q7 vehicles. The Gross Axle Weight Rating (GAWR) listed on the certification label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims," and Part 567, "Certification."
Original — Risk if Unfixed
An overloaded vehicle can increase the risk of a crash.
Original — Remedy
Dealers will install an overlay label containing the correct rear GAWR on top of the existing safety certification label, free of charge. Owner notification letters were mailed April 24, 2023. Owners may contact Audi's customer service at 1-800-253-2834. Audi's number for this recall is 50G5.
