Skip to main content

2005 TOYOTA Avalon

7 recalls Risk Grade: B Most severe issue: Critical

All recalls are free to repair at your local dealership. Contact your dealer to schedule service.

Known Safety Recalls

Critical #10V499000 Plain English
Component

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Manufacturer
TOYOTA MOTOR NORTH AMERICA, INC.
What Happened
The brake master cylinder is a critical part that helps control your brakes. In certain 2004-2006 Toyota and Lexus models, a specific type of brake fluid that's used can cause a seal to dry out and potentially leak slowly over time.
Risk if Unfixed
If brake fluid starts leaking from the seal, you might notice a change in the feel of your brake pedal, and eventually, your brakes could become less effective. This could lead to a higher risk of a crash, especially if you're driving in an emergency situation.
Free Fix
Your Toyota or Lexus dealer will replace the faulty seal with a new, improved one at no cost to you. This repair is completely free, so be sure to schedule it as soon as you receive the recall notice.
Show original NHTSA language
Original — What Happened
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
Original — Risk if Unfixed
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Original — Remedy
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Critical #05V227000 Plain English
Component

STEERING:COLUMN

Manufacturer
TOYOTA MOTOR NORTH AMERICA, INC.
What Happened
The steering column in your vehicle connects your steering wheel to the wheels. Unfortunately, the steering yoke in certain models wasn't properly attached to the steering shaft.
Risk if Unfixed
If the yoke comes loose, you might lose control of your vehicle while driving, which could cause a crash.
Free Fix
Your Toyota dealer will inspect and replace the steering column assembly, free of charge, to ensure it's securely attached. This repair is free, so schedule it as soon as possible.
Show original NHTSA language
Original — What Happened
ON CERTAIN PASSENGER VEHICLES, THE STEERING YOKE WAS NOT WELDED TO THE STEERING SHAFT. IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT THE YOKE MAY COME OFF FROM THE SHAFT, AND COULD RESULT IN A LOSS OF VEHICLE STEERING CONTROL.
Original — Risk if Unfixed
LOSS OF CONTROL OF THE VEHICLE COULD RESULT IN A CRASH.
Original — Remedy
DEALERS WILL INSPECT THE STEERING YOKE AND SHAFT WELD CONDITION, AND REPLACE THE STEERING COLUMN ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MAY 2, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
High Priority #06V096000 Plain English
Component

AIR BAGS

Manufacturer
TOYOTA MOTOR NORTH AMERICA, INC.
What Happened
The airbag inflator in your vehicle is a crucial safety device that deploys in a crash to cushion you in your seat. Unfortunately, a small number of inflators were made with too little of the special gas that makes them work properly.
Risk if Unfixed
If your airbag doesn't inflate fully in a crash, you're at a higher risk of getting hurt. This could lead to serious injury in the event of a collision.
Free Fix
Your Toyota, Scion, or Lexus dealer will replace the faulty airbag inflator with a new one, free of charge. You should schedule the repair as soon as you get the recall notice, and contact the manufacturer's customer service line for assistance.
Show original NHTSA language
Original — What Happened
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Original — Risk if Unfixed
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Original — Remedy
DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Low Priority #16V396000 Plain English
Component

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Manufacturer
Southeast Toyota Distributors, LLC
What Happened
Your vehicle has aftermarket seat heaters with copper strand heating elements that are connected to your seats. These heaters are not from the original equipment manufacturer.
Risk if Unfixed
If the wiring gets damaged when you sit on the seat, the heating element could short circuit and start a fire. This is a serious risk.
Free Fix
Your dealership will disconnect the seat heaters at no cost to you. You'll also get a full refund for the seat heater accessory you purchased. You should schedule the repair as soon as you get the recall notice.
Show original NHTSA language
Original — What Happened
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Original — Risk if Unfixed
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Original — Remedy
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Low Priority #10V036000 Plain English
Component

EQUIPMENT:OTHER:LABELS

Manufacturer
SOUTHEAST TOYOTA DISTRIBUTORS, LLC
What Happened
Your vehicle is missing a label that shows the maximum weight your car can handle. This label is required by law, and it helps prevent you from overloading your vehicle.
Risk if Unfixed
If you overload your vehicle, it could lead to a crash, which could put you and others at risk.
Free Fix
Your dealer will mail you the correct label, or you can visit them to have it installed for free. This is a complimentary service to ensure your safety on the road.
Show original NHTSA language
Original — What Happened
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Original — Risk if Unfixed
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Original — Remedy
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Under Review #10V017000 Plain English
Component

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Manufacturer
TOYOTA MOTOR NORTH AMERICA, INC.
What Happened
The accelerator pedal in your vehicle has a small part called the friction lever that helps the pedal move smoothly. Over time, this lever can become worn out and cause the pedal to become harder to press or stick in one position.
Risk if Unfixed
If the pedal gets stuck, you could lose control of your vehicle, especially if you're driving at high speeds. This increases the risk of a serious accident.
Free Fix
Your Toyota dealer will install a reinforcement bar in the accelerator pedal to fix the problem and ensure smooth operation. This repair is completely free, so you shouldn't have to pay a thing.
Show original NHTSA language
Original — What Happened
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Original — Risk if Unfixed
THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Original — Remedy
DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Under Review #09V388000 Plain English
Component

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Manufacturer
TOYOTA MOTOR NORTH AMERICA, INC.
What Happened
The accelerator pedal in your vehicle is the part that you press to make the car go faster. It can get stuck in the wide open position if the floor mat gets trapped under it.
Risk if Unfixed
If the pedal gets stuck, your car could speed up uncontrollably and become hard to stop. This could cause a serious crash, injury, or even death.
Free Fix
Toyota will fix your vehicle at no cost to you. They'll modify the accelerator pedal and floor mat to prevent the pedal from getting stuck. They'll also give you a new, redesigned floor mat or repurchase the old one if you don't want the new one. Additionally, some models will get a software update that makes the brakes override the accelerator if both pedals are pressed at the same time.
Show original NHTSA language
Original — What Happened
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Original — Risk if Unfixed
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Original — Remedy
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →

Browse by Component

VEHICLE SPEED CONTROL
2 recalls
SERVICE BRAKES, HYDRAULIC
1 recall
STEERING
1 recall
AIR BAGS
1 recall
SEATS
1 recall
EQUIPMENT
1 recall

Other TOYOTA Avalon Years

2021
2 recalls
2020
3 recalls
2019
4 recalls
2018
2 recalls
2017
2 recalls
2016
3 recalls
2015
2 recalls
2014
4 recalls
2013
4 recalls
2012
4 recalls
2011
1 recall
2010
7 recalls
2009
7 recalls
2008
6 recalls
2007
6 recalls
2006
7 recalls
2004
3 recalls
2003
2 recalls
2002
1 recall
2001
2 recalls
2000
2 recalls

Related Pages

2005 Honda Accord Recalls 2005 Nissan Altima Recalls 2004 TOYOTA Avalon Recalls 2006 TOYOTA Avalon Recalls All TOYOTA Recalls TOYOTA Avalon Recall History