Skip to main content

2006 GMC Envoy

9 recalls Risk Grade: C+ Most severe issue: Critical

All recalls are free to repair at your local dealership. Contact your dealer to schedule service.

Known Safety Recalls

Critical #05V455000 Plain English
Component

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Manufacturer
GENERAL MOTORS CORP.
What Happened
The power steering hose in your vehicle is a critical component that helps you turn the wheels easily. In your vehicle, there's a chance that the hose isn't up to spec, which could cause a problem.
Risk if Unfixed
If the hose fails under extreme driving conditions, you could lose power steering and power brake assist, making it harder to steer and brake. This could lead to an increase in steering effort and braking effort, and in the worst case, if the power steering fluid gets on hot engine parts, it could start a fire.
Free Fix
Your authorized dealer will inspect the power steering hose and replace it if it's one of the suspect parts. This repair is free, and you should schedule it as soon as you get the recall notice.
Show original NHTSA language
Original — What Happened
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Original — Risk if Unfixed
IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Original — Remedy
DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
High Priority #06V417000 Plain English
Component

AIR BAGS:FRONTAL

Manufacturer
GENERAL MOTORS CORP.
What Happened
The passenger air bag sensing system in your vehicle is a safety feature that helps decide whether to deploy the front passenger air bag. However, if you've had aftermarket leather seat covers installed, they might interfere with this system.
Risk if Unfixed
If the passenger air bag sensing system fails because of the seat covers, the air bag might not deploy when it should, or it might deploy when it shouldn't. This could increase the risk of injury to the front passenger in a crash.
Free Fix
Unfortunately, a new leather seat cover that's compatible with the passenger sensing system isn't available. As a result, General Motors will repurchase your vehicle to ensure your safety, and you should contact them at 1-877-477-1022 to start the repurchase process.
Show original NHTSA language
Original — What Happened
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Original — Risk if Unfixed
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Original — Remedy
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Moderate #15V599000 Plain English
Component

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Manufacturer
General Motors LLC
What Happened
The power window switch in your vehicle is the part that lets you roll your windows up and down. In some 2006-2007 Buick, Chevrolet, and GMC models, this switch can get water inside and corrode, causing it to malfunction.
Risk if Unfixed
If the switch corrodes, it could lead to a fire, even if your vehicle is parked and not in use. This is a serious situation that could cause damage to your vehicle and surrounding property.
Free Fix
Your dealer will install a new, water-resistant power window switch at no cost to you. This repair is free, and you should schedule it as soon as you get the recall notice.
Show original NHTSA language
Original — What Happened
General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the affected vehicles may have had their master power window switch module treated with a protective coating, instead of having it replaced.
Original — Risk if Unfixed
The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.
Original — Remedy
GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 15700.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Moderate #15V519000 Plain English
Component

EXTERIOR LIGHTING:HEADLIGHTS

Manufacturer
General Motors LLC
What Happened
Your vehicle's headlight driver module is a computer that controls your headlights and daytime running lights. In some affected models, this module can overheat and fail, turning off your headlights.
Risk if Unfixed
If your headlights don't work, it's harder for you to see the road at night, and other drivers can't see your vehicle as well. This increases the risk of a crash or being involved in an accident.
Free Fix
Your dealership will replace the faulty headlight driver module with a new one, free of charge. You should schedule the repair as soon as possible to ensure your safety on the road.
Show original NHTSA language
Original — What Happened
General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.
Original — Risk if Unfixed
Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.
Original — Remedy
GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Moderate #14V404000 Plain English
Component

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Manufacturer
General Motors LLC
What Happened
The power window switch on your car is controlled by a small computer module. In some 2005-2007 Saab, Chevrolet, Buick, and GMC vehicles, fluid can leak into this module, causing it to corrode and potentially fail.
Risk if Unfixed
If the module fails, the power locks and windows might not work properly, and the door module could overheat, causing a fire that could burn your vehicle even when it's parked and not in use, risking injury or damage.
Free Fix
Your dealer will inspect the module and replace it with a new one, free of charge, as soon as parts are available. In the meantime, it's best to park your vehicle outside until the repair is done to avoid any potential risks.
Show original NHTSA language
Original — What Happened
General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Original — Risk if Unfixed
A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Original — Remedy
GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Moderate #13V248000 Plain English
Component

ELECTRICAL SYSTEM

Manufacturer
General Motors LLC
What Happened
The driver's door module in your vehicle controls the power locks and windows. It's the part with the circuit board that makes these functions work. In some 2005-2007 models, water may seep into the module and cause corrosion, which can lead to a short circuit.
Risk if Unfixed
A short in the circuit board could cause a fire, even when the car is parked and not in use. This could lead to injuries or property damage.
Free Fix
Your dealer will check the driver's door module and either apply a protective coating or replace it if it's not working properly – both of which are free of charge. You'll be contacted when it's time for the repair, and you should schedule it as soon as possible.
Show original NHTSA language
Original — What Happened
General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Original — Risk if Unfixed
A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Original — Remedy
Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Moderate #12V406000 Plain English
Component

ELECTRICAL SYSTEM

Manufacturer
General Motors LLC
What Happened
The electrical system in your vehicle contains a module that controls your power door lock and window switches. In certain models, water could leak into this module, causing a short circuit that could lead to a fire.
Risk if Unfixed
A short circuit in the module could cause a fire, even when your vehicle is parked and not in use. This could lead to a serious injury or property damage.
Free Fix
When parts become available, your dealer will replace the door module, free of charge. You'll receive a notice with instructions on how to schedule the repair. In the meantime, as a precaution, you should park your vehicle outside.
Show original NHTSA language
Original — What Happened
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Original — Risk if Unfixed
A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Original — Remedy
Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Moderate #07E014000 Plain English
Component

EXTERIOR LIGHTING:HEADLIGHTS

Manufacturer
MAXZONE AUTO PARTS CORPORATION
What Happened
Your headlight assembly is a crucial part that helps you see the road at night. Some aftermarket Depo brand headlight assemblies, made for certain vehicles, were misshapen during production, affecting their aiming position.
Risk if Unfixed
If your headlight is not pointing correctly, you might not be able to see the road ahead clearly, which could increase the risk of a collision.
Free Fix
Maxzone will notify you and offer a reimbursement for the non-compliant headlight assembly. You should contact them at 909-822-3288 to get the process started, and the repair is at no cost to you.
Show original NHTSA language
Original — What Happened
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NO 335-1120L-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION THE LAMP HOUSING SHAPE DEFORMED DISTORTING THE ASSEMBLY ANGLE OF THE REFLECTOR AND INFLUENCED THE AIMING POSITION. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Original — Risk if Unfixed
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Original — Remedy
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON FEBRUARY 16, 2007. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →
Low Priority #05V552000 Plain English
Component

EQUIPMENT:OTHER:LABELS

Manufacturer
GENERAL MOTORS CORP.
What Happened
Your vehicle's tire and loading information label lists the correct weight capacity, but there's a mistake on the label – it's not accurate. This label is like a guide for how to load your vehicle safely and check tire pressure.
Risk if Unfixed
If you rely on the incorrect label, you might load your vehicle or inflate your tires incorrectly, which could cause a tire to fail. This increases the risk of a crash.
Free Fix
You'll get a corrected label and instructions from the manufacturer, and you can choose to have a dealer install it for you at no cost. When you receive the recall notice, schedule an appointment with your dealer to get the correct label installed.
Show original NHTSA language
Original — What Happened
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Original — Risk if Unfixed
A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Original — Remedy
OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
View full recall details → Repairs are free at any authorized dealer. Find a dealer →

Browse by Component

VISIBILITY
2 recalls
EXTERIOR LIGHTING
2 recalls
ELECTRICAL SYSTEM
2 recalls
STEERING
1 recall
AIR BAGS
1 recall
EQUIPMENT
1 recall

Other GMC Envoy Years

2007
5 recalls
2005
3 recalls
2004
2 recalls
2003
8 recalls
2002
14 recalls
2001
1 recall
2000
1 recall

Related Pages

2005 GMC Envoy Recalls 2007 GMC Envoy Recalls All GMC Recalls GMC Envoy Recall History