The 2004 FORD E-250 has a risk grade of F. This grade is calculated from 18 NHTSA safety recalls, weighted by severity, recency, and temporal decay. Grades range from A+ (excellent) to F (avoid).

The 2004 FORD E-250 has 18 known safety recalls on record. All recalls are repaired free of charge at authorized dealerships.

The most severe recall for the 2004 FORD E-250 is classified as critical. This indicates a life-threatening safety issue that should be addressed promptly.

This model year has 18 recorded safety recalls. Model-level listings do not establish VIN-specific open recalls or whether this vehicle is safe to drive. Check your VIN and contact the manufacturer for recall instructions.

FORD IS RECALLING CERTAIN REPLACEMENT FUEL TANKS THAT COULD BE INSTALLED INTO MODEL YEAR 2004 THROUGH 2008 E-150, E-250, AND E-350 VANS AND WAGONS. THE AFFECTED FUEL TANKS HAVE AN EXTRA OBDII SENSOR HOLE ON THE TOP OF THE TANK THAT MAY NOT BE PROPERLY SEALED AND MAY LEAK FUEL. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE. FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE FUEL TANKS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 28, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-800-232-5952.

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED. FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR. UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

ON CERTAIN VANS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES. THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. THE RECALL BEGAN SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.

ON CERTAIN VANS, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT. THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED. DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.

QUALITY VANS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2006 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT. THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY. QUALITY VANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR QUALITY VANS AT 1-480-464-7007.