Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Risk if Unfixed
If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Free Fix
Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.
Your vehicle may have a faulty trim panel clip that wasn't replaced correctly during a previous entertainment system installation.
Risk if Unfixed
If the airbags deploy, the trim panel could detach and hit you, which could cause injury.
Free Fix
A free replacement of the trim panel clip will be done by the dealership, and you'll be notified when it's time to bring your vehicle in.
Show original NHTSA language
Original — What Happened
Gulf States Toyota, Inc. (GST) is recalling certain model year 2015 Toyota Sienna vehicles manufactured January 23, 2015, to April 13, 2015, and equipped with non-Toyota-brand overhead entertainment accessories installed by GST. During reassembly of the interior after the overhead entertainment system installation, a trim panel securing clip may have been reused instead of being replaced.
Original — Risk if Unfixed
If the clip was damaged during the entertainment system installation, in the event of a side curtain air bag deployment, the trim panel may detach and strike one of the vehicle occupants, increasing the risk of injury.
Original — Remedy
GST will notify owners, and dealers will replace the trim panel securing clip, free of charge. The recall began June 5, 2015. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 15R1.
Your vehicle's trim panel securing clip, which holds the roof and pillars in place, might not be properly secured due to a manufacturing issue.
Risk if Unfixed
If the airbags deploy in a crash, the trim panel could break loose and hit you or a passenger, causing injury.
Free Fix
Don't worry, it's free! Your dealership will replace the trim panel securing clip at no cost to you.
Show original NHTSA language
Original — What Happened
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2015 Sienna vehicles manufactured September 1, 2014, to April 13, 2015 and equipped with overhead entertainment accessories installed by SET. During reassembly of the interior after the overhead entertainment system installation, a trim panel securing clip may have been reused instead of being replaced.
Original — Risk if Unfixed
If the clip was damaged during the entertainment system installation, in the event of a side curtain air bag deployment, the trim panel may detach and strike one of the vehicle occupants, increasing the risk of injury.
Original — Remedy
SET will notify owners, and dealers will replace the trim panel securing clip, free of charge. The recall began on May 22, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET15B.