Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Risk if Unfixed
Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Free Fix
Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles previously repaired incorrectly under recall numbers 23V-199 or 22V-255. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Risk if Unfixed
A disconnected driveshaft can result in vehicle rollaway when the vehicle is placed in park without the parking brake applied. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Free Fix
Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S22.
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Risk if Unfixed
A disconnected driveshaft can result in a loss of drive power or a vehicle rollaway if the parking brake is not applied. Either of these scenarios can increase the risk of a crash.
Free Fix
Dealers will replace the subframe bushing and rear axle bolt. They will also inspect the rear axle cover for damage near the bolt hole location and replace with a new cover if any damage is found. Repairs will be performed free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S55.
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Manufacturer
Ford Motor Company
What Happened
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Risk if Unfixed
Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Free Fix
Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Manufacturer
Ford Motor Company
What Happened
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.
Risk if Unfixed
A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.
Free Fix
Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles equipped with a 2.0L or 3.3L engine and a 10 Speed Automatic Transmission with the All Wheel Drive package. The drive shaft may fracture along the weld seam.
Risk if Unfixed
Defective drive shafts may fail and cause a loss of connection between the transfer case and rear axle, possibly resulting in a vehicle rollaway when in Park or a loss of drive. Either condition can increase the risk of a crash. The drive shafts can also deform and separate from the driveline and potentially contact the fuel tank, increasing the risk of fuel leaks and/or fire.
Free Fix
Ford will notify owners, and dealers will inspect the drive shaft label inspected and replace it as necessary, free of charge. The recall began December 11, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S65.
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer
Ford Motor Company
What Happened
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."
Risk if Unfixed
Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.
Free Fix
Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.
This model year has 7 recorded safety recalls. Model-level listings do not establish VIN-specific open recalls or whether this vehicle is safe to drive. Check your VIN and contact the manufacturer for recall instructions.
What is the POWER TRAIN:AUTOMATIC TRANSMISSION recall for the 2020 FORD Explorer? (Campaign #26V402000)
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage. Park system damage may result in a vehicle rollaway, increasing the risk of a crash. Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
What is the POWER TRAIN:DRIVELINE:DRIVESHAFT recall for the 2020 FORD Explorer? (Campaign #25V166000)
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles previously repaired incorrectly under recall numbers 23V-199 or 22V-255. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect. A disconnected driveshaft can result in vehicle rollaway when the vehicle is placed in park without the parking brake applied. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash. Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S22.
What is the POWER TRAIN:DRIVELINE:DRIVESHAFT recall for the 2020 FORD Explorer? (Campaign #23V675000)
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect. A disconnected driveshaft can result in a loss of drive power or a vehicle rollaway if the parking brake is not applied. Either of these scenarios can increase the risk of a crash. Dealers will replace the subframe bushing and rear axle bolt. They will also inspect the rear axle cover for damage near the bolt hole location and replace with a new cover if any damage is found. Repairs will be performed free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S55.
What is the POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM) recall for the 2020 FORD Explorer? (Campaign #23V199000)
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect. Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash. Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
What is the POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM) recall for the 2020 FORD Explorer? (Campaign #23V069000)
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage. A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash. Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.