The 2019 CHEVROLET 5500HD has a risk grade of D. This grade is calculated from 4 NHTSA safety recalls, weighted by severity, recency, and temporal decay. Grades range from A+ (excellent) to F (avoid).

The 2019 CHEVROLET 5500HD has 4 known safety recalls on record. All recalls are repaired free of charge at authorized dealerships.

The most severe recall for the 2019 CHEVROLET 5500HD is classified as critical. This indicates a life-threatening safety issue that should be addressed promptly.

This model year has 4 recorded safety recalls. Model-level listings do not establish VIN-specific open recalls or whether this vehicle is safe to drive. Check your VIN and contact the manufacturer for recall instructions.

General Motors. LLC (GM) is recalling certain 2019-2023 Chevrolet 4500HD, 5500HD, and 6500HD Medium-Duty trucks. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause an electrical short-circuit. An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the master cylinder pressure sensor and inspect the wire harness, replacing it, if necessary, free of charge. Owner notification letters were mailed July 11, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222375270.

Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2015-2017 Isuzu NPR, Reach, 2016-2020 Isuzu NPR XD, NPR HD, NQR, 2016-2021 Isuzu NRR, 2017-2020 Chevrolet 4500XD, 4500HD, 5500HD, and 2020 Chevrolet 5500XD vehicles. The U-bolt nuts for the rear axle may not have been properly tightened and may loosen, causing the axle to misalign. The misalignment may cause the propeller shaft to separate, causing a loss of power to the rear wheels and a stall, increasing the risk of a crash. Isuzu will notify owners, and dealers will inspect and, if needed, replace and tighten the rear axle U-bolt nuts, free of charge. The recall began on April 23, 2021. Owners may contact Isuzu customer service at 1-866-441-9638. Isuzu's number for this recall is V2103.

Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2017-2020 NPR-HD, 2019-2020 NPR-XD, NQR, NRR, Chevrolet 4500HD, Chevrolet 5500HD and Chevrolet 5500XD, and 2020 Chevrolet 4500XD vehicles. The lug nuts on the rear outer wheels may not have been properly tightened when installed onto the rear axles. If the lug nuts were not properly tightened, they can loosen, causing the to wheel separate from the vehicle, increasing the risk of a crash. Isuzu will notify owners, and dealers will inspect the rear outer wheel lug nuts and tightening or replacing them as necessary, free of charge. The recall began December 20, 2019. Owners may contact Isuzu customer service at 1-866-441-9638 or Chevrolet customer service at 1-800-222-1020. Isuzu's number for this recall is V1906.

General Motors is recalling certain 2019-2020 Chevrolet 4500HD, 5500HD, and 6500HD Medium Duty trucks. If the vehicle's body control module (BCM) loses communication with the vehicle's electronic brake control module (EBCM), the EBCM software programming may not illuminate the vehicle's ABS malfunction indicator light (MIL). As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) Number 105, "Hydraulic and Electric Brake Systems." If a driver is unaware that the ABS system is malfunctioning, there may be an increased risk of a crash. GM will notify owners, and dealers will update the software calibration for the body control module (BCM). The recall began June 29, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202305070.